Condition
|
Cause
|
Correction
|
| Rattling noise |
Poorly adjusted roof lid |
Adjust roof lid |
|
Excess play in slides or guide pins |
See Service Bulletin 54
01 84 (298) |
|
Water drain connector knocking on rail |
Tape over rivets on rail |
|
Guide tubes vibrating against each other |
Tape guide tubes |
|
Liner frame hitting lid when open |
Install foam rubber on corners of frame. |
| Roof raises but does not slide |
Pins bent on gate holders |
Replace gate holders |
| Water leaking through roof |
Poorly adjusted roof |
Adjust roof lid |
|
Damaged or loose seals |
Replace seals |
|
Drain hoses plugged |
Clean drain hoses |
|
Incorrect seals fitted |
Check for correct orientation of seals |
|
Rails and cover plates not sealed against body |
Remove rails and
seal mating surface |
| Grinding noise on open or close |
No lubrication on rails |
Apply grease to all moving parts |
| Grinding noise on raising roof |
Front seal dry |
Lubricate with Vaseline or equivalent |
|
Too much pressure on front seal |
Adjust roof lid |
| Roof lifts unevenly |
Drive cables out of adjustment |
Adjust cables |
|
Cable no longer secured in guide |
Squeeze guides onto cables to secure |
| Whistling noise from closed roof |
Poorly adjusted roof |
Adjust roof lid |
| Electric drive motor does not run |
Blown fuse |
Replace fuse |
|
Motor defective |
Replace motor |
|
Switch defective |
Replace switch |
|
Wire harness defective |
Locate and repair break |
| Roof does not lift |
Defective relay |
Replace relay |
|
Poor adjustment of roof |
Adjust roof lid |
| Sunroof goes past closed, to lift, without stopping |
Microswitch defective |
Replace
microswitch |
| Motor runs but roof does not move |
Insufficient contact force on drive clutch |
Adjust clutch |
